頁籤選單縮合
題 名 | pH、液固比之變動對底渣中重金屬Pb、Cd溶出之影響=The Effect of pH and Liquid/Solid Ratio on the Leaching of Lead and Cadmium from Bottom Ashes of Incinerators |
---|---|
作 者 | 林奇剛; 秦孝偉; 凌永健; 陳建豐; 許民昇; 彭彥翔; | 書刊名 | 東南學報 |
卷 期 | 35 2010.07[民99.07] |
頁 次 | 頁129-138 |
分類號 | 445.545 |
關鍵詞 | 超音波震盪; 焚化底渣; 重金屬溶出; 酸萃取; 環境衝擊; Ultrasound sonication; Bottom ash; Heavy metals leachate; Acidic extraction; |
語 文 | 中文(Chinese) |
中文摘要 | 摘 要 目前台灣地區業界將底渣再利用於級配混凝土、瀝青土、空心磚等建材上,但礙 於法規重金屬含量合格限制,必須進行相關前處理才能進行後續再利用。於利用過程 中,環境條件不同下,可能導致重金屬或其它物質析出。 本研究以變動pH 及液固比(L/S)結合超音波震盪法(UST)對底渣中重金屬(Pb、Cd) 去除成效、重量、溫度及之探討。於強度試驗中,探討不同酸強度對重金屬析出量之 影響(pH = 3.5及pH = 4.5)。當pH = 3.5時,其Pb 之累計溶出量多寡順序為0.53 mg/L(L/S=5.0)>0.34 mg/L(L/S = 2.5),而pH =4.5時,為0.29 mg/L(L/S = 5.0)>0.24 mg/L(L/S = 2.5)。而Cd 部份,無論是模擬酸鹼值約為4.5左右或是考量降低資源化風 險、增加強度而降低酸鹼值為3.5左右,經UST,其上澄液底渣重金屬Cd 完全未被檢 出。同時,由數次分析結果發現,底渣重金屬全含量起伏明顯、穩定性不高,此對底 渣在資源化作業上,額外增加必須排除的難題。此外,以pH 分別調控於4.5及3.5時, 底渣與萃取酸脫水反應而削減重量約5.24%~6.94%,隨後再經TCLP 溶出處理後,底 渣的重量再次削減約少2.48%~6.64%,底渣累計重量減損約8.84%~12.72%。由此試 驗結果推斷,若是底渣長期受到酸雨環境,其重量應有明顯的減損。另外,經UST 試 驗後pH 值趨於中性或弱鹼性,而溫度由起始約24.4~27.9℃上升至50℃~60℃,反應 後之溫度又下降至室溫。經過以上試驗結果,底渣經UST 反應後去除重金屬物質後, 並不會對環境造成其他影響及二次污染之虞。 |
英文摘要 | ABSTRACT The effects of heavy metals, Pb, Cd, eliminated utilized acidic extraction together Response of Heavy Metal Elimanation in Bottom Ash to Operation of pH and Liquid to Solids Ratio Shock with ultrasound sonication treatment (UST) from incinerated bottom ash were studied. The principle parameters considered in this study were the liquid to solid ratio, the concentrations and varieties of acidic extraction solutions, reaction time and strength of sonication. L/S ratio and acidic extraction intensity have a remarkable impact on abatement of amount of bottom ashes treated with extraction. The weight change of ashes will be measurable for a long term exposure of acid rain. The pHwas turned into neutral or weak base while temperature was increased to 50 to 60 ℃ by UST treatment and decreased to room temperature. |
本系統中英文摘要資訊取自各篇刊載內容。