查詢結果分析
相關文獻
- 具流動聚焦霧化機制之內衝式微霧化器性能研究
- 氣管插管併發咽食道破裂--病例報告
- Unusual Presentation of Heterotopic Pregnancy: A Case Report
- 敏化304不銹鋼在高溫純水環境中應力腐蝕電化學雜訊反應
- 急性挫傷性視網膜色素壞死--兩病例報告
- 合金元素(銅,鈦)對縮墨鑄鐵破裂韌性之影響
- 片狀石墨鑄鐵動態與靜態韌性關係之研究
- Spontaneous Uterine Rupture during Pregnancy
- SAE1017鋼管壓扁裂之問題分析
- Left Atrial Rupture Following Blunt Chest Trauma--A Case Report
第1筆 /總和 1 筆
/ 1 筆
頁籤選單縮合
題名 | 具流動聚焦霧化機制之內衝式微霧化器性能研究=Atomization Performance of Internal-Impinging Type Micro-Atomizer with Flow Focusing Mechanism |
---|---|
作者 | 王覺寬; 楊坤和; 楊哲睿; | 書刊名 | 航空太空及民航學刊. 系列B |
卷期 | 40:2 2008.10[民97.10] |
頁次 | 頁69-76 |
分類號 | 448.57 |
關鍵詞 | 微霧化器; 流動聚焦; 內衝式; 霧化機制; 破裂; Micro atomizer; Flow focusing; Internal-impinging; Twin-fluid; Breakup; |
語文 | 中文(Chinese) |
中文摘要 | 本研究應用微機電(MEMS)技術製作具流動聚焦機制之內衝式微霧化器(MMA),其噴口水力直徑(D(下標 h))爲45及78μm,由邊鞘之層流氣流以48度角衝擊並推送此液束至噴口外碎化成噴霧流。結果顯示,低氣液質量比下,出現氣泡爆破(bubble bursting)、單液滴噴流及分岔之液滴噴流現象,在較高之氣液質量比下則出現紊流霧化模態。當D(下標 h)=45μm,液體流率爲1.0mL/min,霧化氣體壓力爲2bar時,可產生平均粒徑(SMD)3μm之噴霧,其中有50%之噴霧液滴小於5μm,77%液滴小於10μm。其霧化品質優於市售之醫用霧化器(NE-C21V),適合運用在ICP質譜儀之液體樣本導入及氣霧給藥等領域。 |
英文摘要 | This paper describes the atomization mechanisms and performance of a twin-fluid micro atomizer with flow focusing. The micro atomizer is fabricated via MEMS bulk micro-machining processes. The orifice hydraulic diameters (D(subscript h)) of the micro atomizers are 45 and 78 μm, respectively. The liquid streams are pushed by the sheath gas flows by an angle of 48 degree in the mixing chamber and are impinged each other at the exit. They are disintegrated into droplets at the exit of the micro-atomizer. Observations of the disintegration of liquid in the near field of the atomizer show that the breakup phenomena involved the mechanisms of bubble bursting, mono-dispersed droplet formation, and flow branching of the liquid jet under lower gas-to-liquid mass ratio. On the other hand, the mechanism of turbulent breakup mode can be observed under higher gas-to-liquid mass ratio. It turns out that the micro-atomizer generates a fine stream with 50% volume fraction less than 5μm and 77% volume fraction of droplets less than 10μm. Furthermore, the mean droplet size of the micro spray is lowered to 3μm under the gas pressure of 2bar and liquid flow rate of 1.0mL/min. The performance of the micro-atomizer compares favorably better than the commercial pneumatic nebulizer. It is very useful in the applications of sample introduction in inductively coupled plasma mass spectrometry (ICP-MS) and medical inhalation devices. |
本系統之摘要資訊系依該期刊論文摘要之資訊為主。