查詢結果分析
來源資料
相關文獻
- 雙螺旋攪拌翼微藻反應器系統之研發
- Kinetic Analysis of Phototroph-containing Activated-sludge Reactors
- Effect of Fuel Loading on Criticality of Low Enriched Uranium Fueled Material Testing Reactors
- Numerical Modeling of Transient Natural Convection Heat Transfer from a Tank-In-Pool Type Reactor
- IIST設施自發式爐心冷卻系統設計及事故分析研究
- Temperature Control of An Aromatic Polyamide Batch Reactor System
- TRR-Ⅱ 反應器中子捕獲治療中子束第一階段概念設計
- On Sensitivity Loss of the Neutron Detectors During Long Operation of MPR
- Taipower's Transient Analysis Methodology for Pressurized Water Reactors
- Theoretical Analysis of a Continuous Bioreactor Subject to Cyclic Feed Concentration
頁籤選單縮合
| 題 名 | 雙螺旋攪拌翼微藻反應器系統之研發=Study and Development of a Reactor System with the Double Helical Ribbons Impeller for Algae |
|---|---|
| 作 者 | 聞元輝; 蘇卓群; 馬聿安; 陳俊明; 尤瓊琦; | 書刊名 | 農林學報 |
| 卷 期 | 59:3 2010.09[民99.09] |
| 頁 次 | 頁253-271 |
| 分類號 | 368.7 |
| 關鍵詞 | 反應器; 大溪地等鞭金藻; 雙螺旋攪拌翼; Reactor; Isochrysis aff. galbana; Double helical ribbons impe; |
| 語 文 | 中文(Chinese) |
| 中文摘要 | 本研究旨在設計開發一套使用雙螺旋攪拌翼之微藻反應器系統,製作完成之系統主要由外部遮蔽本體、培養槽體、攪拌裝置及自動控制系統所構成,其中控制系統包括 pH迴饋控制、進排液控制、溫度控制、光照及曝氣等單元,具備自動連續、單動及手動控制模式。經由基本性能測試,獲致開啟 4、8與 12只植物燈光照強度分別為 2600、5200與 6500 lux;攪拌軸轉速於變頻控制在 0-60 Hz,獲致實際可操作之變頻範圍在 0-30 Hz之間,其相對應之轉速則介於 0-172 rpm,並經迴歸分析獲致其變頻數值與攪拌軸轉速之數學關係式,進而可依據此關係式獲得設定轉速之變頻值。系統自動化半連續之自動循環模式培養試驗,在光照強度、pH值、溫度與攪拌軸轉速設定分別為 6500 lux、7.0±0.5 pH、25℃與 50 rpm(變頻數值 8.7Hz),並以稀釋率 16.67% (20/120)、接種比例 5:1 (83.33%)與有效培養水體 120公升條件下,連續培養 20天之測試結果,顯示本反應器系統可生產高濃度之藻細胞,並獲致每日收穫定量平均濃度約為 667.27×104 cells/ml之藻體溶液 20公升,而其稀釋後平均濃度則約為 443.97×104 cells/ml,且單日生長速率常數與攪拌翼能量消耗平均約為 0.3997 day-1與 1.21 kwh,亦顯示本研究之藻類反應器已具備穩定且可長時間培養大溪地等鞭金藻之能力。 |
| 英文摘要 | The reactor system developed in this research based on the double helical ribbons impeller was constructed and combined together with the parts of the outer cover unit, the cultivating tank, the stirring device and the automatic control system. The automatic control system was integrated with the pH value feedback control unit, the solution inlet and outlet control unit, the temperature control unit, the illumination control unit and the aeration control unit, and held three operation modes such as the auto-continuous control process, the single control process and the manual control process, respectively. Based on the fundamental performance test, the illumination condition could be changed to 4, 8 and 12 light sources with the respected illuminance of 2600, 5200 and 6500 lux. The rotation speed of the stirring shaft could be varied using an indirect circuit frequency controller between frequencies 0 and 60 Hz. The valuable range of frequencies obtained was between 0 and 30 Hz, while the related rotation speeds were between 0 and 172 rpm. A regression equation between the relation of rotation speed and frequency was also established, which could be used to set the frequency of the controller as the rotation speed required. During 20 days of the automatic semi-continuous cultivating experiment, the cultivating conditions were set with the illuminance of 6500 lux, the rotation speed of 50 rpm, the pH value of 7±0.5, the temperature of 25 ℃, the daily dilution ratio of 16.67% (20/120), the daily inoculate rate of 5:1 (83.33%) and the valid cultivating volume of 120 l. The experimental results showed that the reactor system could produce a high concentration solution of the algal cell. The daily harvested amount of the algal cell solution was 20 liters with the average harvesting concentration 667.27×104 cells/ml, and the average concentration of the algal cell after dilution was about 443.97×104 cells/ml. The daily average growth rate constant and the daily average impeller energy consumption obtained were 0.3997 day-1 and 1.21kwh, respectively. The experiment also verified that the reactor system presently developed in this research obtained the capabilities of stable and long-term cultivating functions for the alga Isochrysis aff. galbana. |
本系統中英文摘要資訊取自各篇刊載內容。